Product ID:UNDERCOAT-WHITE ALKYD
MSDS Date:08/19/1999
FSC:8010
NIIN:00-664-0019
Status Code:A
MSDS Number: CLNCP

Emergency Phone: 1-800-663-4057

Info Phone: 248-661-0260

Preparer: ERNEST CARTER

Cage: 6X798

Telephone: 248-661-0260, FAX 248-661-3941

Cage: 6X798

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 2900 MG/M3;500 PPM

ACGIH TLV: 525 MG/M3;100 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Effects of Overexposure:BREATHING OF HIGH VAPOR CONCENTRATIONS MAY
PRODUCE NARCOSIS. LIQUID MAY CAUSE MINOR SKIN IRRITATION AND
DEFINITE EYE IRRITATION.HARMFUL IF INHALED. MAY AFFECT THE BRAIN OR
NERVOUS SYSTEM CAUSING. DIZZ INESS, HEADACHE OR NAUSEA. CAUSES EYE
IRRITATION. CAUSES PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
INTENTION MISUSE BY DELIBERATELY CONCENTRATING & INHALING CONTENTS
MAY BE HARMFUL OR FATAL.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT A
PHYSICIAN. SKIN CONTACT: FLUSH WITH WATER. EYE CONTACT: FLUSH
IMMEDIATELY WITH LARGE AMOUNTS OF WATER. CONSULT A PHYSICIAN. IF
SWALLOWED, GET MEDICAL ATTENTION IMMEDIATELY.

Flash Point Method:SCC
Flash Point:=37.8C, 100.F
Lower Limits:1.0%
Upper Limits:8.0%
Extinguishing Media:CO2 DRY CHEMICAL FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED GAS MASK FOR FIRE
FIGHTING PERSONNEL.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. VAPORS
MAY MIGRATE TO IGNITION SOURCE AND CAUSE FLASH FIRE.

Spill Release Procedures:IN CASE OF SPILLAGE ABSORB WITH INERT MATERIAL
AND DISPOSE OF IN ACCORDANCE WITH APPLICABLE REGULATIONS OF E.P.A.
AND OTHER LOCAL, STATE, AND FEDERAL AUTHORITIES.

Handling and Storage Precautions:STORE AWAY FROM HEAT, SPARKS AND OPEN
FLAME. AVOID PROLONGED SKIN CONTACT. DO NOT BREATHE SPRAY MIST.
STORE IN A COOL DRY AREA WITH VENTILATION SUITABLE FOR STORING
MATERIALS SHOWN IN SECTION II
Other Precautions:GROUND CONTAINERS WHILE POURING. AVOID SPONTANEOUS
COMBUSTION OF CONTAMINATED RAGS OR OTHER ORGANIC MATERIALS, EMPTY
CONTAINERSA MAY RETAIN HAZARDOUS PROPERTIES AND CAN BE DANGEROUS.

Respiratory Protection:NIOSH/OSHA APPROVED RESPIRATOR TYPES SUITABLE
FOR MATERIALS IN SECTION 11 RECOMMENDED. APPROVED
CHEMICAL/MECHANICAL FILTERS RECOMMENDED WHEN VENTILATION IS
RESTRICTED. DO NOT BREATH (DUST, VAPORS OR S PRAY MIST). WEAR
APPROPRIATE, RESPIRATOR (NIOSH/MSHA APPROVED) DURING & AFTER
APPLICATION. UNLESS AIR MONITORING RECORDS VAPOR/MIST LEVELS BELOW
APPLICABLE LIMI
Ventilation:SUFFICIENT VENTILATION,IN VOLUME AND PATTERN, SHOULD BE
PROVIDED TO KEEP AIR CONTAMINATION BELOW CURRENT APPLICABLE OSHA
PERMISSIBLE.
Protective Gloves:CHEMICAL RESISTANT PLASTIC OR RUBBER .
Eye Protection:CHEMICAL GOGGLES WITH SIDE SHIELDS OR FACE SHIELD
RECOMMENDED.
Other Protective Equipment:AS REQUIRED TO AVOID WETTING CLOTHES. USE
PROTECTIVE CREAMS WHERE SKIN CONTACT IS LIKELY . REMOVE AND WASH
CONTAMINATED CLOTHING BEFORE REUSE. EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES, SKIN, AND CLOTHING.
WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health

Boiling Pt:B.P. Text:300-400 F
Vapor Density:HEAVIER
Spec Gravity:1.3856
VOC Pounds/Gallon:327
VOC Grams/Liter:2.73
Evaporation Rate & Reference:SLOWER THAN BUTYL
Appearance and Odor:LIQUID CHARACTERISTIC
Percent Volatiles by Volume:42.7%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OR OPEN FLAME.
Conditions to Avoid Polymerization:WILL NOT OCCUR UNDER NORMAL
CONDITIONS.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS DISPOSE OF PRODUCT IN
ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.